Multiquip DCA150SSJU3 Manuel d'utilisateur Page 57
- Page / 102
- Table des matières
- DEPANNAGE
- MARQUE LIVRES
Noté. / 5. Basé sur avis des utilisateurs
DCA150SSJU3 50 HZ GENERATOR • OPERATION AND PARTS MANUAL — REV. #1 (02/01/10) — PAGE 57
CHECK OIL LEVEL
Check the crankcase oil level prior to each use, or when the
fuel tank is fi lled. Insuffi cient oil may cause severe damage
to the engine. Make sure the generator is level. The oil
level must be between the two notches on the dipstick as
shown in Figure 29.
Replacing Oil Filter
Remove the old oil fi lter.
Apply a fi lm of oil to the gasket on the new oil fi lter.
Install the new oil fi lter.
After the oil cartridge has been replaced, the engine oil
will drop slightly. Run the engine for a while and check for
leaks before adding more oil if needed. Clean excessive
oil from engine.
FLUSHING OUT RADIATOR AND REPLACING
COOLANT
Open both cocks located at the crankcase side and at
the lower part of the radiator and drain coolant. Open
the radiator cap while draining. Remove the overfl ow
tank and drain.
Check hoses for softening and kinks. Check clamps for
signs of leakage.
Tighten both cocks and replace the overfl ow tank.
Replace with coolant as recommended by the engine
manufacturer.
Close radiator cap tightly.
Flush the radiator by running clean tap water through
radiator until signs of rust and dirt are removed. DO
NOT clean radiator core with any objects, such as a
screwdriver.
WARNING
Allow engine to cool when fl ushing out
radiator. Flushing the radiator while hot
could cause serious burns from water or
steam.
RADIATOR CLEANING
The radiator (Figure 62) should be sprayed (cleaned) with
a high pressure washer when excessive amounts of dirt
and debris have accumulated on the cooling fi ns or tube.
When using a high pressure washer, stand at least 5 feet
(1.5 meters) away from the radiator to prevent damage to
the fi ns and tube.
Figure 62. Radiator Cleaning
GENERATOR STORAGE
For long term storage of the generator the following is
recommended:
Drain the fuel tank completely. Treat with a fuel stabilizer
if necessary.
Completely drain the oil from the crankcase and refi ll if
necessary with fresh oil.
Clean the entire generator, internal and external.
Cover the generating set and store in a clean, dry place.
Disconnect the battery.
Make sure engine coolant is at proper level.
If generator is mounted on a trailer, jack trailer up and
place on blocks so tires do not touch the ground or block
and completely remove the tires.
MAINTENANCE
- MODEL DCA150SSJU3 1
- PROPOSITION 65 WARNING 2
- REPORTING SAFETY DEFECTS 3
- DCA150SSJU3 Generator 4
- PARTS ORDERING PROCEDURES 5
- SAFETY INFORMATION 10
- SPECIFICATIONS 12
- DIMENSIONS 13
- INSTALLATION 14
- GENERAL INFORMATION 16
- MAJOR COMPONENTS 17
- DIAGNOSTIC DISPLAY 18
- LOAD RPM 22
- BATT VOLT 22
- OIL PRES 22
- ENGINE OIL PRESSURE 23
- GAGE NOT RESPONDING 23
- USE DEFAULTS 28
- CUSTOM SETUP 28
- AUTOMATIC SCAN OFF 28
- GENERATOR CONTROL PANEL 35
- ENGINE OPERATING PANEL 36
- OUTPUT TERMINAL PANEL 38
- 100 VAC GFCI Receptacles 39
- Hookup Panel) 39
- Connecting Loads 40
- Over Current Relay 40
- LOAD APPLICATION 41
- GENERATOR OUTPUTS 42
- VOLTAGE GAUGES 43
- AC Voltmeter Gauge Reading 43
- AC Ammeter Gauge Reading 43
- UVWO TERMINAL OUTPUT VOLTAGES 44
- INSPECTION/SETUP 46
- INCORREC 50
- Figure 46. Frequency Meter 51
- Figure 47. Frequency Meter 51
- STARTING (AUTO MODE) 53
- NORMAL SHUTDOWN PROCEDURE 54
- EMERGENCY SHUTDOWN PROCEDURE 54
- MAINTENANCE 55
- TRAILER MAINTENANCE 59
- TRAILER WIRING DIAGRAM 63
- GENERATOR WIRING DIAGRAM 64
- ENGINE WIRING DIAGRAM 65
- TROUBLESHOOTING (GENERATOR) 66
- SAMPLE PARTS LIST 68
- NO. Column 68
- PART NO. Column 68
- QTY. Column 68
- REMARKS Column 68
- SUGGESTED SPARE PARTS 69
- GENERATOR ASSY 70
- CONTROL BOX ASSY 72
- ENGINE AND RADIATOR ASSY 76
- OUTPUT TERMINAL ASSY 80
- BATTERY ASSY 82
- MUFFLER ASSY 84
- FUEL TANK ASSY 86
- ENCLOSURE ASSY 88
- ENCLOSURE ASSY. (CONTINUED) 90
- RUBBER SEALS ASSY 94
- NAMEPLATE AND DECALS ASSY 96
- OPERATION AND PARTS MANUAL 102
Produits connexes et manuels pour Générateurs Multiquip DCA150SSJU3
(92 pages)
(120 pages)Cobra Electronics XRS9430 manuales
Manuales del propietario y guías del usuario para Deportes y recreación Cobra Electronics XRS9430.
Ofrecemos 1 manuales en pdf Cobra Electronics XRS9430 para descargar gratis por tipos de documentos: Manual de usuario
Commentaires sur ces manuels